- Post is under moderationULTIMATE MODIFIED BMW
Stunning 800whp turbo M10-powered 2002 is like a gift from the gods…
With an astonishing 800whp from its turbo’d M10, this wild 2002 is about as quick as any sane person would want to travel. Words: Elizabeth de Latour. Photos: Christos Karagiorgakis.
2002: A PACE ODYSSEY
Think of Greece and you will no doubt think of crisp, white houses sitting before the bluest sea you’ve ever seen, beautiful beaches, and delicious food. Perhaps what you won’t think of is modified BMWs. However, having been to Greece on many previous BMW-based visits, we can tell you that there are some serious machines scattered across the country. And this right here might just be the most serious piece of German modified machinery that Greece has to offer. It belongs to Stavros Panagopoulos, who has owned it for ten years. This was, in fact, his very first #BMW : a humble 1602 that he found for sale near his house. As you can probably tell, it’s changed a bit since then…
Stavros says he entered into ’02 ownership with plans to make the diminutive classic just a little bit faster. And while he’s certainly achieved his end goal, and then some, he didn’t embark on a journey of turbocharged madness from the off; there were at least two slightly more sensible stages prior to what you see here. Things started off normally enough, with the 1.6-litre four-cylinder engine enhanced with twin side draft 40 carbs. And that was fine, but not quite enough for Stavros’s liking. So Stage two was a bit more dramatic. The original engine was deemed not quite large enough so it was removed and in its place went a more powerful 2.0, its potency ramped-up considerably with the addition of a 300-degree camshaft, Weber 48 DCOE carbs, MSD Ignition components, and a selection of other sexy engine enhancements. That’s pretty solid and we wager the car (that was now by definition a 2002) must have been a whole load of fun to drive and a massive step up over how it felt originally. And then something happened: Stavros decided that what he really wanted was an 800whp turbo conversion. Because, sometimes, that’s just what you need in your life…
As you might imagine, making that sort of underbonnet magic happen takes more than a little bit of work and the engine spec list reads like a who’s who of the performance tuning scene. It’s thorough and it’s glorious. It’s the modified BMW enthusiast’s equivalent of 50 Shades of Grey…
Step one, you’ve got to get your engine choice down. Stavros opted for the sturdy M10, which served as the basis for BMW’s insane turbocharged M12 motorsport engine as well as the S14, so it’s certainly up to the task of coping with a spot of turbocharging.
But the example nestling under this ’02’s bonnet is very far removed from your common-or-garden M10, as you might have guessed. There’s a lot in the engine bay, so much so that you can barely even see the engine, but if it looks impressive from the outside, there’s plenty to get excited about on the inside, too. 89mm CP forged pistons have been fitted, along with Carrillo forged rods, a custom reprofiled camshaft from Boubis Cams, and #VAC-Motorsports valves, rocker arms, valve guides and valve springs. Somewhere within the engine bay (you’ll have to take our word for it because it’s buried deep beneath seemingly endless pipework) sits the very core of all that power: an absolutely gigantic #Garrett-GTX4202R-turbo . This beast of a snail is rated up to 1150hp so Stavros has plenty of headroom, running as he is at around the 900hp mark, should he ever decide that’s not quite enough. This is useful, actually, as his next goal is to hit 1000hp…
When it came to getting everything squeezed into the engine bay, custom is most definitely the word of the day: the turbo feeds a HPS custom intake manifold via a suitably massive front-mounted intercooler and sits on a custom exhaust manifold that connects up to a custom exhaust with an external wastegate that exits through the sill just behind the passenger side front wheel.
The exhaust manifold and the turbo housing itself have both been treated to a Zircotec ceramic coating. Stavros has also had massive Bosch Motorsport 1600cc/min injectors fitted to supply enough fuel to keep the engine happy, along with a custom HPS oil pan. The whole lot is looked after by an Autronic SM4 stand-alone ECU.
Seeing as no one involved in the designing and construction of the ’02 family could ever have imagined that someone in the distant future would attempt to pass somewhere in the region of 900hp through the compact runabout, Stavaros has had to go to town on the transmission and chassis to ensure it didn’t tear itself to pieces. The gearbox is a five-speed manual Getrag unit from the E28 535i mated to a custom twin-plate clutch that can handle the immense amount of power and torque being developed by the engine, with an E34 M5 rear axle tasked with transferring everything to the rear tyres. On the suspension front, this 2002 has been fitted with E36 M3 underpinnings, including subframes and wishbones, with #KW coilovers up front and Bilstein dampers at the back. While it doesn’t take much to stop a car as small and light as a 2002, stopping one that’s travelling at close to the speed of sound does require something a little more substantial, and this example certainly doesn’t mess about. Up front sit AP Racing Galfer four-pot calipers clamping 305mm vented discs. The rear setup is no less substantial, with another set of AP Racing four-pot calipers wrapped around slightly smaller 255mm vented discs.
When it came to the exterior Stavros decided to keep things relatively subtle in as much that a casual observer might not be aware of what’s been changed but, at the same time, it’s clear that this 2002 is far from standard. It’s actually about as aggressive as a 2002 can really get. The biggest difference are those pumped-up arches, complete with sill extensions that fill out the flanks. They give the normally unassuming classic some real road presence. Having the wastegate exiting through the sill certainly doesn’t hurt, and neither does that fat, single-tipped exhaust pipe. Of course, fitting wide arches is one thing, having suitable wheels that are substantial enough to fill them is another matter entirely but Stavros’ choice definitely doesn’t disappoint, though it might raise a few eyebrows. He’s taken the classic cross-spoke look that sits so well with the 2002 and turned it on its head with a set of decidedly modern Work VS-XXs.
The 17” wheels are positively huge on the compact classic but they look fantastic, really filling out those big arches, especially with the car dropped low over the fat rubber. Even parts of the body that may look stock aren’t. For example, the bonnet and boot might appear to be relatively standard, bar the pins and catches, but they are both carbon fibre items, with twin fuel fillers on the rear deck for the bootmounted alloy fuel cell. The one thing the 2002 isn’t is heavy, so adding carbon panels and reducing the already low weight further still means that, with 800whp on tap, this car is absolutely insane – just in case you hadn’t gathered that already!
With a build like this the interior could go a number of ways: hardcore, stripped-out; stock and subtle; or, option three, custom, luxurious but still decidedly sporty – which is exactly what Stavros has gone for. The interior is dominated by those gorgeous Recaro A8 seats and both they, the rear seats, the doorcards, the steering wheel centre section, the gear gaiter and the handbrake have all been covered in the same delicious shade of caramel leather.
Something that’s easier to miss is the custom alloy roll-cage; it’s so well-integrated that, while you can clearly see the rear diagonal support, the sections that penetrate the dashboard (down into the footwell) and the rear parcel shelf are much more discreet.
Up front, the gauge cluster has been replaced with an AIM MXL digital racing dash while the centre console now resembles the flight deck of an aircraft rather than a car. Where the central air vents would have once been there now sits a quartet of custom-mounted GReddy exhaust temperature gauges and below that another custom panel that houses a Daemon boost gauge, A’Pexi turbo timer and fuel gauge and, finally, down in front of the illuminated gear lever, you’ll find a pair of GReddy pressure gauges.
We’ve featured some pretty wild 2002s over the years but this example might just ‘take the cake’. It’s an utterly incredible machine and we’re a little bit in love with it. We love how the custom wide-arches give the little 2002 a broad, square stance. We love the interior, with its blend of modern tech, race components and gorgeous leather. And we really love the engine; we doubt you’ll see a more complicated engine bay, there’s just so much stuffed under the bonnet. And to come away with 800whp from such a small engine and to have it at your disposal in such a small, lightweight car is utterly insane and, well, we love that too.
TECHNICAL DATA FILE #BMW-2002-Turbo / #Garrett-GTX4202 R / #Garrett / #BMW-2002 / #M10-Turbo / #Getrag / #BMW / #BMW-2002-800bhp /
ENGINE AND TRANSMISSION 2.0-litre four-cylinder #M10 / #BMW-M10 / , CP forged pistons, #Carrillo forged rods, #Boubis-Cams custom reprofiled camshaft, #AC-Motorsports valves, rocker arms, valve guides and valve springs, Garrett GTX4202R turbo with Zircotec ceramic-coated housing, #Zircotec ceramiccoated custom exhaust manifold, external wastegate, custom exhaust system, #HPS custom intake manifold, #Bosch-Motorsport 1600cc/min injectors, #HPS custom oil pan, #Autronic #Autronic-SM4 stand-alone ECU, Autronic ignition, #Getrag fivespeed manual E28 535i gearbox, custom twin disc clutch kit
CHASSIS 7.5x17” (front and rear) #Work-VS-XX wheels with 205/40 (front) Yokohama AVS Sport and 245/45 (rear) Dunlop SP Sport MAXX tyres, E36 M3 subframe, wishbones etc, #KW coilover kit (front), #Bilstein dampers (rear), E34 M5 rear axle, #AP-Racing Galfer four-pot calipers with 305mm vented discs (front) and AP Racing four-pot calipers with 255mm vented discs (rear)
EXTERIOR Carbon fibre bonnet, carbon fibre boot, custom wide-arch conversion
INTERIOR Custom alloy roll-cage by Ilias Makropoulos, #Recaro A8 seats, rear seats, doorcards, steering wheel centre section, gear gaiter and handbrake finished in caramel leather, illuminated M gear knob, AIM MXL digital racing dash, custom-mounted #GReddy exhaust temperature gauges, pressure gauges, Daemon boost gauge, A’Pexi turbo timer, alloy fuel cell
Engine looks monstrously complicated, and it is, with a huge amount of custom work at every turn and a gigantic #Garrett-GTX402R turbo buried deep within.Stream item published successfully. Item will now be visible on your stream.