We’ve all worked on #MG s and #Triumph s, or maybe changed the occasional starter motor on a Mustang, These relatively simple backyard jobs give us a tremendous sense of pride and accomplishment, especially when they turn out well. Does your car run better when you’ve washed it, waxed it and really cleaned the windscreen? I know it’s mostly psychological, but it does seem to be true.
My first car was actually a truck. A #1934-Ford-pick-up with a flat-head V8. It was easy to change the plugs and adjust the carburettor. I remember opening the hood of a friend’s #1968 #Mustang at the time and thinking, oh my God, what a complicated mess this is. Compared with today’s vehicles, that ’ #1968-Ford-Mustang engine seems like a single-cylinder lawnmower.
I have a friend with a late-model BMW . When the battery went dead, the dealer told him not to change it himself because it would negate all the codes on the car’s computer. So he had it towed to the dealer, they changed the battery and it cost $600. Had he known to run jumper cables to the positive and negative terminals to keep the computer codes alive, he could have done the job himself for a third of the price.
The greatest gift to buy yourself if you have a modern car is a code-reader to plug into your onboard diagnostic (OBD) system. When I took my 2005 SLR Mercedes-McLaren to be smog-tested, the ‘check engine’ light was on. I listened politely as my dealer explained all the expensive parts that needed to be replaced. I thanked him, went back to my garage, plugged in my code-reader and got a reading of 442. That pertained to the EVAP system, which prevents petrol vapour from escaping from your fuel system into the atmosphere. It usually requires no maintenance but can turn your ‘check engine’ light on.
Your fuel system up to the tank is pressurised, so a loose petrol cap can activate the light, but it wasn’t that. My next thought was the gasket on the gauge sender unit - after all, the car’s 15 years old - but after dismantling the rear of the SLR I found no dampness or weeping there.
This was getting scary. How much more of this car do I have to dismantle? I decided to follow the fuel lines, and I came to a plastic T-fitting that had a hairline crack in it. Not enough to leak fuel, but perhaps enough to suck air? As I examined this fitting it broke in my hand. Could it be this simple? Never a fan of plastic fittings - after all, this one had lasted only 15 years - I got one made of brass, installed it, tightened all the fittings... and voila! The ‘check engine’ light was out.
I plugged in my code reader, the code had cleared. I drove it to the smog station and passed the test, the cost, about three bucks. My little $30 code-reader had saved me thousands of dollars. I have to admit that accomplishing this little task was as much fun as actually driving the car. Rather than looking like a rich guy driving it around, I had actually fixed my automobile.
Old cars are simple but faults can be hard to diagnose. New cars are very complex, but with code-readers you can find the problem quickly. Who’d have thought it?
My second supercar problem concerned my #2005-Ford-GT . It ran fine but would not pass the California smog test. Once again, I plugged in my handy code-reader and it told me that all my codes were fine, except for the catalytic converter, The dealer told me how much a catalytic converter would cost and how complicated it was to install. ‘After all, Mr Leno, the car is 15 years old.’
Could it be something else? I took the car for a long drive and noticed the temperature gauge was reading about 160°F. Most modern supercars tend to run close to 200°F. Asking around, I ascertained that the GT was running too cool to activate the computer that regulated the catalytic converter. We pulled out the thermostat and found that a build-up of limescale was holding it open, so it was allowing more cooling water through than was necessary.
I picked up a new thermostat at my Ford dealer, that’s the thing about a Ford GT: it might be a supercar, but it’s still a Ford. Once it was installed, the car ran at between 195 and 205 degrees. I took it for a drive, about 15 miles at 45mph, plugged in my code-reader and all the codes read OK, including the catalytic converter. I then drove to the smog station and passed the test. Supercars might be complicated, but they’re still cars. And for all the electronics that make supercars complicated, there are other electronics that help make life easier.
‘THE CODE CLEARED AND THE SLR PASSED THE SMOG TEST. MY LITTLE $30 CODE-READER HAD SAVED ME THOUSANDS’
Do yourself a favour. Buy a halfway-decent code-reader and find your modern car’s OBD port, then, the next time your dealer tells you ‘This is going to be complicated’, why not just plug it in and find out for yourself?
No feeds imported yet